INNOVATIVE CHEMICAL CORPORATION
711 NORTHLAND AVENUE
BUFFALO, NEW YORK 14211
PHONE: 716-883-4000 FAX: 716-892-1171
MATERIAL SAFETY DATA SHEET
--------------------------
MAY BE USED TO COMPLY WITH OSHA’S HAZARD COMMUNICATION STANDARD, 29 CFR 1910.1200. STANDARD MUST BE CONSULTED FOR SPECIFIC REQUIREMENTS.
---------------------------------------------------------------------
MANUFACTURER’S NAME: PREPARED BY
WORLD MARKETING OF AMERICA, INC. QC Supervisor 10/18/99
---------------------------------------------------------------------
SECTION I-IDENTIFICATION
---------------------------------------------------------------------
TRADE NAME: PRODUCT CODE:
KERO KLEAN IC037
DOT CLASS:
FLAMMABLE LIQUID
CHEMICAL NAME:
MIXTURE
---------------------------------------------------------------------
SECTION II-HAZARDOUS INGREDIENTS/IDENTITY INFORMATION
---------------------------------------------------------------------
HAZARDOUS COMPONENTS CAS # OSHA PEL ACGIH TLV
METHYL ALCOHOL 67-56-1 250 PPM 250 PPM
ALL OTHER COMPONENTS ARE CONSIDERED NON-HAZARDOUS PER OSHA 29CFR 1910.1200
PLEASE NOTE THAT THE CHEMICAL IDENTITY AND PERCENT COMPOSITION OF SOME OR ALL OF THE ABOVE HAZARDOUS INGREDIENTS IS CONFIDENTIAL BUSINESS INFORMATION AND IS BEING WITHHELD AS PERMITTED BY 29CFR 1910.1200 AND VARIOUS STATES RIGHT TO KNOW LAWS.
----------------------------------------------------------------------
SECTION III-PHYSICAL/CHEMICAL CHARACTERISTICS
----------------------------------------------------------------------
BOILING POINT: 147 F
SPECIFIC GRAVITY (H20=1): 0.80
VAPOR PRESSURE (MM Hq): 47.300 mmHG @ 60 F
MELTING POINT: ND
VAPOR DENSITY (AIR=1): ND
EVAPORATION RATE (BUTYL ACETATE=1): 2.1 (N=BUTYL ACETATE)
SOLUBILITY IN WATER: SOLUBE
% VOLATILE BY WEIGHT: ND
WEIGHT (LB/GAL): 6.65
% SOLIDS: ND
VISCOSITY: (BROOKFIELD) ND
PH: ND
APPEARANCE AND ODOR: CLEAR LIQUID, PINE ODOR
----------------------------------------------------------------------
SECTION IV-FIRE AND EXPLOSION HAZARD DATA
----------------------------------------------------------------------
FLASH POINT (TAG CC) 54 DEG. F. LEL OHL 6.0 36.0
EXTINGUISHING MEDIA: CO2, DRY CHEMICAL. FOAM.
SPECIAL FIRE FIGHTING PROCEDURES: S.C.B.A. & BUNKER GEAR RECOMMENDED.
UNUSUAL FIRE AND EXPLOSION HAZARDS: TOXIC FUMES, GASES OR VAPORS MAY EVOLVE ON BURNING.
-----------------------------------------------------------------------
SECTION V-REACTIVITY DATA
-----------------------------------------------------------------------
STABILITY: STABLE
CONDITIONS TO AVOID: KEEP AWAY FROM HEAT, SPARKS OR OPEN FLAME. KEEP CONTAINERS TIGHTLY CLOSED, WASH HANDS AFTER HANDLING.
INCOMPATIBILITY (MATERIALS TO AVOID): ALKALIS, STRONG OXIDIZING AGENTS, ACIDS, AMINES AND CHLORO COMPOUNDS.
HAZARDOUS DECOMPOSITION BYPRODUCTS: CO, CO2.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
-----------------------------------------------------------------------
SECTION VI-HEALTH HAZARD DATA
-----------------------------------------------------------------------
ACUTE HEALTH HAZARDS: INGESTION MAY CAUSE RED BLOOD CELL HEMOLYSIS AND POSSIBLE LIVER AND KIDNEY DAMAGE.
CHRONIC HEALTH HAZARDS: MAY CAUSE CHRONIC HEALTH EFFECTS BASED ON DATA WITH LABORATORY ANIMALS, (SEE ABOVE).
CARCINOGENICITY: UNKNOWN
SIGNS AND SYMPTOMS OF EXPOSURE
EYES: VISUAL IMPAIRMENT (INCLUDING BLINDNESS)
DERMAL: IRRITATION, DEFATTING, REDNESS.
INHALATION: MAY CAUSE DIZZINESS, HEADACHES, NAUSEA, AND VOMITING.
INGESTION: NAUSEA, VOMITING, ABDOMINAL CRAMPS, AND IRRITATION OF THE GASTROINTESTINAL LINING.
EMERGENCY AND FIRST AID PROCEDURES
EYES: FLUSH WITH LARGE AMOUNTS OF COOL WATER FOR 15 MINUTES. IF IRRITATION PERSISTS, CONTACT A PHYSICIAN.
DERMAL: WASH WITH SOAP & WATER AND RINSE THOROUGHLY. REMOVE CONTAMINATED CLOTHING.
INHALATION: REMOVE PERSON TO FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN, GET MEDICAL ATTENTION.
INGESTION: GIVE CONSCIOUS PERSON WATER OR MILK TO DILUTE. INDUCE VOMITING.
----------------------------------------------------------------------
SECTION VII-PRECAUTIONS FOR SAFE HANDLING AND USE:
----------------------------------------------------------------------
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
LARGE SPILLS: PICK UP AS MUCH AS POSSIBLE AND PLACE IN CONTAINERS FOR DISPOSAL. RESIDUAL LIQUID CAN BE ABSORBED ON INERT MATERIAL.
SMALL SPILLS: SAME AS FOR LARGE SPILLS.
WASTE DISPOSAL METHOD: CONSULT LOCAL, STATE & FEDERAL REGULATIONS.
----------------------------------------------------------------------
SECTION VIII-CONTROL MEASURES
----------------------------------------------------------------------
RESPIRATION PROTECTION (SPECIFY TYPE): USE NIOSH/MSHA APPROVED COMBINATION ORGANIC VAPOR AND HIGH EFFICIENCY FILTER CARTRIDGE IN HIGH CONCENTRATION AREAS.
VENTILATION: GOOD AIR CIRCULATION, EXHAUST VENTILATION FOR MISTS OR VAPORS.
PROTECTIVE GLOVES: NON-PERMEABLE BUTYL.
EYE PROTECTION: GOGGLES, OR FULL FACE SHIELD IS RECOMMENDED.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: SUFFICIENT TO PROTECT AGAINST PROLONGED SKIN CONTACT.
WORK/HYGIENIC PRACTICES: ALWAYS WASH HANDS & FACE BEFORE CONSUMING FOOD OR BEVERAGES OR WHENEVER CONTACT ON THE SKIN.
----------------------------------------------------------------------
SECTION IX-NOTES: NOTE TO PHYSICIAN:
----------------------------------------------------------------------
NONE.
HAZARD RATING
HEALTH 1
FLAMMABILITY 3
REACTIVITY 0
----------------------------------------------------------------------
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE; HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF.
VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSON PROXIMATELY CAUSED BY THE MATERIAL IF REASONABLE SAFETY PROCEDURES ARE NOT ADHERED TO AS STIPULATED IN THE DATA SHEET. ADDITIONALLY, VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR THIRD PERSONS PROXIMATELY CAUSED BY ABNORMAL USE OF THE MATERIAL EVEN IF REASONABLE SAFETY PROCEDURES ARE FOLLOWED. FURTHERMORE, VENDEE ASSUMES THE RISK IN HIS USE OF THE MATERIAL. |
